Keystone Cougar recalls
- Keystone shock bolts may have been incorrectly tightened. 2024–2026 Keystone Alpine, Cougar, Montana +1 more
- Keystone pin box fasteners may have been improperly tightened. 2025 Keystone Arcadia, Cougar
- Keystone may have been manufactured without an emergency exit window. 2022 Keystone Cougar
- Dutchmen electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation. 2022 Dutchmen Aspen Trail, Coleman, Colorado +13 more
- Keystone base may have incomplete welds that are unable to hold the intended weight, causing the table/bed base to drop unexpectedly. 2022 Keystone Cougar
- Keystone improper clearance may allow the tires to contact the outrigger, causing damage to the tires. 2019 Keystone Cougar
- Keystone solar controller may be incorrectly wired, causing certain components and safety alarms, such as carbon monoxide and propane gas detectors, to become inoperable. 2021–2022 Keystone Alpine, Arcadia, Avalanche +13 more
- Keystone manufactured with Load Range "D" (2540 lbs) tires, when they should have been equipped with Load Range "E" (2860 lbs) tires. 2022 Keystone Cougar
- Dutchmen regulator may fail, causing an increase in propane pressure. 2019 Dutchmen Aspen Trail, Coleman, Kodiak +11 more
- Keystone frame rails do not have enough cross support, which could cause them to buckle under certain side-load stress conditions. 2017 Keystone Cougar
- Keystone inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use. 2021 Keystone Cougar
- Keystone solar Prep wiring to the 12VDC breakers located by the battery may not be connected to the protected side of the breaker. 2021 Keystone Cougar
- Keystone inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use. 2020 Keystone Cougar
- Keystone antenna may separate from the mounting base during transit, becoming a road hazard. 2019 Keystone Carbon, Cougar, Fuzion +2 more
- Keystone interior range cooktop is installed in a cabinet that may not be entirely sealed from the furnace cavity. 2020 Keystone Cougar
- Keystone wiring for the solar preparation kit may have been incorrectly wired to the wrong side of the 12V breaker, potentially allowing an electrical short circuit in the event of damage to the wiring. 2020 Keystone Cougar
- Keystone 60"x29" emergency exit windows over the dinette table in the cabin are missing a red handle and "exit" label. 2020 Keystone Cougar
- Dutchmen inner hub bearings of the axles may not have been sufficiently greased, which can cause the bearings to overheat and fail. 2019 Dutchmen Aerolite, Atlas, Bullet +5 more
- Crossroads axles may be missing inner bearing races on the hubs, which can cause the bearing to burnout or cause the hub to overheat. 2019 Crossroads Sunset, Aerolite, Atlas +6 more
- Keystone outdoor propane grill is installed in a wooden assembly that may not have enough clearance from the heated area. 2018 Keystone Cougar
- Keystone propane compartment may not have been sealed properly during manufacturing, which if there were a propane leak, could allow the propane gas to seep into the living quarters. 2019 Keystone Cougar
- Crossroads list of the affected trailer models is available at: https://static.NHTSA.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. 2003–2018 Crossroads Altitude, Belair, Blackwood +116 more
- Keystone stabilizer jacks may not have been properly welded to the chassis frame, possibly resulting in the jacks detaching from the trailer during transit. 2017 Keystone Cougar
- Keystone built with a manual-resetting 12 volt circuit breaker, which cannot be used in close proximity to the liquid propane storage. 2017 Keystone Cougar
- Keystone affected vehicles may have been incorrectly equipped with two carbon monoxide detectors instead of one smoke detector and one carbon monoxide detector. 2017 Keystone Cougar, Laredo
- Keystone during installation, the propane gas cross tube manifold that connects the propane cylinders may have contacted the fasteners for the floor decking. 2017 Keystone Cougar
- Keystone affected trailers have a Federal Identification Tag and Tire and Loading Information Label with incorrect information. 2017 Keystone Cougar
- Dutchmen in the affected vehicles, the screws that attach the expanding room to the sliding mechanism cable may fail allowing the room to extend unintentionally while the vehicle is in motion. 2015 Dutchmen Aerolite, Denali, Kodiak +15 more
- Dutchmen for a full list of the specific models and floor plans affected, see RCLRPT-15V207-4161.PDF under "Associated Documents." In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break. 2015 Dutchmen Aspen Trail, Coleman, Denali +9 more
- Keystone affected vehicles may have been built with frame spring hangers that may be brittle and susceptible to fracturing. 2014 Keystone Bullet, Cougar, Springdale +1 more
- Keystone in the affected vehicles, the inner wheel bearings on the axle may have insufficient lubrication. 2014 Keystone Bullet, Cougar, Hide Out +2 more
- Keystone if the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. 2013–2014 Keystone Alpine, Avalanche, Bullet +15 more
- Keystone rear bumper, which holds the spare tire assembly, may experience metal fatigue causing the spare tire to separate from the vehicle. 2010 Keystone Cougar
- Keystone fail to comply with the requirements of part 567, "certification." the subject vehicles were manufactured with a label that lists the maximum tire pressure of 80psi instead of the correct maximum pressure of 65psi. 2007 Keystone Cougar
- Keystone axles are installed backwards causing a slight reduction in braking torque and shortened brake lining service life. 2011 Keystone Cougar, Laredo
- Keystone official notice describes a safety defect, but the details were not provided in plain language. 2010 Keystone Cougar, Laredo, Outback
- Keystone "spring clip" PLUG-IN assembly may break or fail to provide sufficient force to maintain a proper electrical connection in the panel board. 2011 Keystone Cougar, Fuzion, Sprinter
- Keystone some of the wheels may have inadequate weld penetration between the outer ring and the center plate due to improper plate alignment. 2011 Keystone Cougar, Energy, Hornet +4 more
- Keystone potential exists for a small fracture within the line delivering gas to the oven cavity burner. 2011 Keystone Avalanche, Bullet, Cougar +16 more
- Keystone have experienced a limited number of failures with its spare tire carriers in particular, the spare tire carriers, when combined with a 16" spare tire and when installed on the bumper of a slide out BIKE/STORAGE rack, may break or crack after time causing the spare tire to fall off. 2008 Keystone Cougar, Laredo
- Keystone on certain fifth wheel and travel trailers, the axle spring shackle nuts may not have been properly tightened. 2007 Keystone Cougar
- Keystone certain travel and fifth wheel trailers may have a deficient axle weld joint between the axle tube and spindle. 2006 Keystone Cougar