Check your VIN

Thomas Built recalls

105 recall campaigns for Thomas Built, newest first.

Models

  1. Thomas Built connector plates for the driver's seat belt anchor and an interior body joint seam may be missing, resulting in insufficient structural reinforcements. 2027 Thomas Built EFX2, HDX2 26V-546 · August 24, 2026
  2. Thomas Built entrance door may fail to open or close when the switch is activated. 2026 Thomas Built HDX2 26V-407 · June 26, 2026
  3. Thomas Built entrance door may fail to open or close when the switch is activated. 2026 Thomas Built HDX2 26V-408 · June 26, 2026
  4. Thomas Built front and mid-body interior joints may have been manufactured incorrectly, resulting in insufficient joint strength. 2027 Thomas Built HDX2 26V-388 · June 12, 2026
  5. Thomas Built driver seat belt anchor may have been installed with inadequate hardware. 2026 Thomas Built HDX2 26V-250 · April 20, 2026
  6. Thomas Built driver seat belt anchor may have been installed with inadequate hardware. 2026 Thomas Built HDX2 26V-251 · April 20, 2026
  7. Thomas Built heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment. 2023 Thomas Built HDX, Saf-T-Liner Efx 26V-086 · February 13, 2026
  8. Thomas Built heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment. 2023 Thomas Built HDX, Saf-T-Liner Efx 26V-087 · February 13, 2026
  9. Thomas Built wheel chair restraint retractor may not lock, preventing the wheelchair from being properly secured. 2025–2026 Thomas Built HDX, Minotour DRW, Saf-T-Liner C2 +2 more 25V-849 · December 9, 2025
  10. Thomas Built rear exterior joints may have been manufactured incorrectly, resulting in insufficient joint strength. 2026 Thomas Built HDX2 25V-694 · October 10, 2025
  11. Thomas Built tie rod castle nut and cotter pin may not be installed properly, which can result in a loss of vehicle steering control. 2025–2026 Thomas Built HDX, HDX2, Saf-T-Liner C2 +2 more 25V-604 · September 11, 2025
  12. Thomas Built emergency Exit Label lettering is too small and may be difficult to read. 2019–2020 Thomas Built HDX, Minotour DRW, Minotour SRW +3 more 24V-555 · July 24, 2024
  13. Thomas Built tie rod may be missing a fastener, allowing the steer arm to detach. 2023 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner C2 Jouley +2 more 23V-259 · April 7, 2023
  14. Thomas Built exterior roof panel was manufactured with insufficient joint strength. 2011 Thomas Built HDX, Saf-T-Liner Efx 22V-762 · October 12, 2022
  15. Thomas Built rear exterior side-body panel was manufactured with insufficient joint strength. 2020 Thomas Built HDX 22V-688 · September 14, 2022
  16. Thomas Built forward seat barriers may not provide sufficient protection to passengers. 2011 Thomas Built HDX 22V-634 · August 19, 2022
  17. Thomas Built engine control module (ECM) may experience an internal short-circuit, which can result in an unexpected engine shut down. 2023 Thomas Built HDX, Saf-T-Liner C2 22V-553 · July 29, 2022
  18. Thomas Built passenger seat frames may crack and rotate from fatigue. 2014 Thomas Built HDX, Saf-T-Liner Efx 22V-510 · July 19, 2022
  19. Thomas Built positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit. 2019 Thomas Built HDX 22V-271 · April 22, 2022
  20. Thomas Built positive battery cable may be routed improperly, allowing it to chafe against the transmission oil cooler hoses, which can cause an electrical short circuit. 2019 Thomas Built HDX 22V-272 · April 22, 2022
  21. Thomas Built daimler Trucks North America, LLC. 2020 Thomas Built HDX 21V-914 · November 22, 2021
  22. Thomas Built gross axle weight rating (gawr) may be improperly stated on the label. 2021 Thomas Built HDX 21V-915 · November 22, 2021
  23. Thomas Built nut for the power cable stud on the alternator may not have been tightened properly, which can cause a loose cable connection. 2020 Thomas Built HDX, Saf-T-Liner Efx 21V-850 · November 2, 2021
  24. Thomas Built fan drive pulley assembly bolts may be incorrect or improperly installed. 2022 Thomas Built HDX 21V-714 · September 15, 2021
  25. Thomas Built power steering hose may be routed with inadequate clearance between the hose and the power cables. 2016 Thomas Built HDX 21V-659 · August 25, 2021
  26. Thomas Built power steering hose may be routed with inadequate clearance between the hose and the power cables, potentially damaging the power steering hose. 2016 Thomas Built HDX 21V-660 · August 25, 2021
  27. Thomas Built these school buses may have been manufactured with an incorrect passenger seat configuration that does not provide the proper amount of seat back protection. 2018 Thomas Built HDX 21V-462 · June 17, 2021
  28. Thomas Built tie rod clamps may be loose, which could result in loose tie rod ends that could break or detach. 2021 Thomas Built HDX, Saf-T-Liner C2 21V-370 · May 19, 2021
  29. Thomas Built sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2018 Thomas Built HDX 21V-327 · May 7, 2021
  30. Thomas Built steering arm and tie rod bolts may have a defective seam that can fracture. 2021 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 21V-255 · April 12, 2021
  31. Thomas Built on certain vehicles, one of the six brake caliper mounting bolts on the driver side steer axle may have been incorrectly tightened. 2021 Thomas Built HDX, Saf-T-Liner Efx 21V-017 · January 20, 2021
  32. Thomas Built lettering on the instruction label for the rear emergency exit window may be too small. 2010 Thomas Built HDX 20V-252 · May 5, 2020
  33. Thomas Built brake caliper mounting bolts may have been insufficiently tightened. 2019 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 20V-126 · March 3, 2020
  34. Thomas Built flex-Plate/Torque Converter fasteners may have been insufficiently tightened. 2018 Thomas Built HDX 19V-831 · November 19, 2019
  35. Thomas Built seats may have been manufactured with styrene blocks that may not provide sufficient impact absorption in certain specific areas around the steel seat frame of the back support. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 19V-712 · October 4, 2019
  36. Thomas Built due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. 2019 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 19V-550 · July 25, 2019
  37. Thomas Built due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. 2019–2020 Thomas Built HDX, Minotour, Saf-T-Liner C2 19V-549 · July 24, 2019
  38. Thomas Built driver side rear brakes may drag. 2010–2017 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 19V-444 · June 11, 2019
  39. Thomas Built affected vehicles may have loose steering tie rod arm bolts. 2018 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 18V-914 · December 19, 2018
  40. Thomas Built brake caliper mounting bolts may have been insufficiently tightened. 2018 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 18V-702 · October 5, 2018
  41. Thomas Built wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. 2015 Thomas Built HDX, Saf-T-Liner C2 18V-560 · August 23, 2018
  42. Thomas Built brake caliper mounting bolts on these vehicles may be insufficiently tightened, allowing the bolts to loosen. 2017 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx 18V-352 · May 29, 2018
  43. Thomas Built wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 18V-253 · April 19, 2018
  44. Thomas Built wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 18V-254 · April 19, 2018
  45. Thomas Built wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 18V-192 · March 26, 2018
  46. Thomas Built wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 18V-193 · March 26, 2018
  47. Thomas Built these extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. 2002 Thomas Built HDX, FS-65, Minotour +1 more 18V-083 · January 30, 2018
  48. Thomas Built under load, the seat belt buckle mount rod can fracture. 2016 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more 17V-729 · November 17, 2017
  49. Thomas Built reinforcement bracket may be missing from the seats that have 3-point seat belts. 2014 Thomas Built HDX, Saf-T-Liner C2 17V-587 · September 21, 2017
  50. Thomas Built reinforcement bracket may be missing from the seats that have 3-point seat belts. 2014 Thomas Built HDX, Saf-T-Liner C2 17V-589 · September 21, 2017