Volvo VN recalls
- Volvo steering knuckles may have been manufactured with insufficiently tightened steering arms. 2026 Volvo VAH, VHD, VN +2 more
- Volvo wheel lug nuts may loosen and allow the wheel to detach. 2026–2027 Volvo VAH, VHD, VN +2 more DO NOT DRIVE
- Volvo power cables may have been improperly routed, which can cause an electrical short. 2025 Volvo VN
- Volvo idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine. 2022–2025 Volvo VN, VNL (4)
- Volvo electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working. 2020 Volvo VAH, VHD, VN +1 more
- Volvo when the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration. 2022 Volvo VN
- Volvo wheel lug nuts may be improperly tightened. 2025 Volvo VHD, VN
- Volvo tie rod assembly ball stud could have been improperly heat treated and can fail. 2025 Volvo VHD, VN
- Volvo tie rod assemblies may contain an improperly heat-treated ball stud that can fail, resulting in a sudden loss of steering control. 2025 Volvo VN DO NOT DRIVE
- Volvo drag link may contain an improperly heat-treated ball stud that can fail, resulting in a sudden loss of steering control. 2025 Volvo VHD, VN, Vnre (Electric) DO NOT DRIVE
- Volvo steering gear may have an improperly seated plug in the valve housing, which can result in a sudden loss of steering control. 2025 Volvo VHD, VN
- Volvo gross Axle Weight Rating (gawr) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded. 2024 Volvo VHD, VN
- Volvo engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected. 2023 Volvo VN
- Volvo passenger side bench seat may be inadequately attached to the floor. 2019 Volvo VHD, VN
- Volvo steering gear fasteners may not be properly tightened. 2023 Volvo VAH, VHD, VN
- Volvo engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall. 2023 Volvo VN
- Volvo steering gears may have been assembled incorrectly, which can cause the gear to fracture. 2022 Volvo VN
- Volvo cabinets may be improperly secured to the walls due to the bolts being installed without the required washers. 2022 Volvo VN
- Volvo in the affected vehicles, when the transmission shift lever is moved from reverse to neutral, the reverse gear may stay engaged. 2016 Volvo VN
- Volvo affected vehicles are equipped with certain Cummins engines whose engine control module (ECM) may short circuit and blow a fuse resulting in the engine stalling without warning. 2016 Volvo VN
- Volvo affected vehicles may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint. 2009 Volvo VN
- Volvo seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. 2002 Volvo VHD, VN
- Volvo inversion valve on the frame may be orientated where contaminants can enter the valve through the exhaust port. 2006–2007 Volvo VHD, VN, VT
- Volvo bottom track that attaches to the arms used to open and close the window may DE-BOND, which results in the glass coming loose at the bottom. 2009 Volvo VN, VNL, VT
- Volvo on certain heavy duty class 8 trucks equipped with dana steering shafts, there is a potential that the steering shaft pinch bolt hole may be incorrectly located. 2007 Volvo VHD, VN, VT
- Volvo on certain heavy duty class 8 trucks, equipped with holland air suspension systems, a transverse beam casting may fracture under normal loads. 2005 Volvo VN
- Volvo on certain trucks equipped with arvinmeritor series 145 and 160 rear drive axles. 2006 Volvo VN
- Volvo on certain trucks, the bolts that retain the universal joint to the yoke at the transmission may not be tightened correctly. 2004 Volvo VN
- Volvo on certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged. 2002 Volvo VN