MCI D4000 recalls
- MCI front door lower curb view glazing material is incorrect. 1988–2018 MCI 102D3, 102DL3, D4000 +9 more
- MCI red beacon lighting on the Threshold Warning System (TWS) may not be bright enough. 2013–2021 MCI D4000, D4500, D4005 +2 more
- MCI fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak. 2019–2021 MCI D4000, D4000 Istv, D4500 +5 more
- MCI main Distribution Panel (MDP) located within the battery compartment contains a circuit board that may fail. 2017–2020 MCI D4000, D4000ISTV, D4500 +6 more
- MCI sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2017–2018 MCI D4000, D4000ISTV, D4500 +5 more
- MCI build-up of debris, corrosion, and/or water flow could cause a high resistance path to ground for the sense stud on the back of the alternator and cause the alternator to produce excessive voltage output, which may exceed the threshold limit currently programmed in the VMM and result in a loss of engine power and vehicle shutdown. 2018 MCI D4000, D4500, D4005 +3 more
- MCI seat belts may not extend from the retracted position, rendering the seat belt unusable. 2015–2018 MCI D4000, D4500, D4005 +3 more
- MCI due to vibrations, the exhaust bellow pipes develop a hole. 2011–2012 MCI D4000, D4000ISTV, D4500 +2 more
- MCI vehicles may have an incorrectly installed exhaust bellow pipe, resulting in a bend in the pipe which can cause its premature failure. 2011 MCI D4000, D4500, D4005 +1 more
- MCI affected buses are equipped with certain Recaro Ergo-M Commercial Bus Driver Seats that have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. 2010–2012 MCI D4000, D4000ISTV, D4500 +3 more
- MCI in the affected vehicles, the fuse block assembly for the heating, ventilation and air conditioning motors in the battery compartment may have been assembled incorrectly. 2015 MCI D4000, D4500, D4005 +1 more
- MCI excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. 2011–2014 MCI D4000, D4500
- MCI due to the excessive power draw of the LED lights, heat may build up at the fuse block and connector, causing the components to melt. 2009–2010 MCI D4000, D4500, D4505
- MCI multiplex electrical systems controller may unintentionally turn off the vehicle's headlights while the vehicle is in gear. 2014 MCI D4000, D4000ISTV, D4500 +3 more
- MCI condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. 2011 MCI D4000
- MCI specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat. 2000–2006 MCI 102D3, 102DL3, 102EL3 +10 more
- MCI in the affected buses, the bellows pipe in the exhaust system may have been incorrectly assembled, which could result in a failure of the pipe during operation. 2012 MCI D4000, D4000ISTV, D4500 +2 more
- MCI due to excessive power draw of the LED lights, heat may build up at the fuse block and connector, causing components to melt. 2009–2010 MCI D4000, D4500, D4505
- MCI under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (ESC) system. 2003–2007 MCI D4000, D4000ISTV, D4500 +4 more
- MCI affected pulley covers may lack certain welds required to keep the covers attached to the coach structure. 2010 MCI D4000, D4500, D4505
- MCI suspect axles may have had improper torque applied to the HUB/ROTOR/WHEEL adapter bolts during the assembly process. 2010 MCI D4000, D4500, E4500 +3 more
- MCI mci has notified NHTSA of a defect in certain model year 2009 D4000 and model year 2008-2010 D4500 and D4505 motor coaches fitted with ricon public use lifts. 2008–2009 MCI D4000, D4500, D4505
- MCI wheelchair lift may become disengaged from a locked position and slide unrestrained on its rollers in the storage structure, potentially breaking through the cassette door and extending beyond the outside of the door when the coach is in motion, particularly when the coach is making a left turn. 2000–2005 MCI D4000, D4500, D4505
- MCI connector board can corrode due to an accumulation of moisture under the connector. 2002–2003 MCI D4000, D4500
- MCI on certain motor coaches equipped with a slide switch to control the defroster blower speed, there is a speed controller for each of the two defroster fan motors. 2001–2003 MCI 102EL3, D4000, D4500 +1 more
- MCI on certain motor coaches that have multiplex systems, when the COACH'S defroster motor is activated, certain high speed cell net controllers (hcnc) may lock up. 2002 MCI D4000, D4500