Check your VIN

MCI D4000ISTV recalls

12 recall campaigns for the MCI D4000ISTV, newest first.

  1. MCI front door lower curb view glazing material is incorrect. 1988–2018 MCI 102D3, 102DL3, D4000 +9 more 25V-853 · December 10, 2025
  2. MCI main Distribution Panel (MDP) located within the battery compartment contains a circuit board that may fail. 2017–2020 MCI D4000, D4000ISTV, D4500 +6 more 21V-748 · September 24, 2021
  3. MCI sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2017–2018 MCI D4000, D4000ISTV, D4500 +5 more 21V-364 · May 18, 2021
  4. MCI due to vibrations, the exhaust bellow pipes develop a hole. 2011–2012 MCI D4000, D4000ISTV, D4500 +2 more 18V-309 · May 13, 2018
  5. MCI affected buses are equipped with certain Recaro Ergo-M Commercial Bus Driver Seats that have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. 2010–2012 MCI D4000, D4000ISTV, D4500 +3 more 16V-020 · January 20, 2016
  6. MCI affected motor coaches have front and steerable tag axles whose tie rod nuts may be improperly torqued. 2014 MCI D4000ISTV, D4500, D4005 +2 more 15V-184 · March 30, 2015
  7. MCI multiplex electrical systems controller may unintentionally turn off the vehicle's headlights while the vehicle is in gear. 2014 MCI D4000, D4000ISTV, D4500 +3 more 14V-370 · June 9, 2014
  8. MCI in the affected buses, the bellows pipe in the exhaust system may have been incorrectly assembled, which could result in a failure of the pipe during operation. 2012 MCI D4000, D4000ISTV, D4500 +2 more 13V-142 · April 16, 2013
  9. MCI thirty minutes after the park brake is set and the ignition is turned off, the entrance door will close without warning. 2012 MCI D4000ISTV, D4500, D4505 12V-086 · March 5, 2012
  10. MCI under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (ESC) system. 2003–2007 MCI D4000, D4000ISTV, D4500 +4 more 11V-524 · October 26, 2011
  11. MCI may have been equipped with meritor wabco steering angle sensors (sas) which can develop internal friction between the sensor gears and the sensor housing as a result of external forces experienced on the vehicle including vibration. 2003–2009 MCI D4000ISTV, D4500, E4500 09V-196 · January 6, 2009
  12. MCI these steering gears contain potentially defective sector shafts with an incorrect gear tooth which may interfere with the RACK-PISTON teeth, resulting in a sticking or binding condition. 2008 MCI D4000ISTV, D4500 08V-063 · July 2, 2008