Thomas Built Buses Saf-T-Liner Efx recalls
- Thomas Built heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment. 2023 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built heater hose clamps may not have been tightened properly, causing the hose to disconnect and leak heating coolant inside the passenger compartment. 2023 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built wheel chair restraint retractor may not lock, preventing the wheelchair from being properly secured. 2025–2026 Thomas Built HDX, Minotour DRW, Saf-T-Liner C2 +2 more
- Thomas Built tie rod castle nut and cotter pin may not be installed properly, which can result in a loss of vehicle steering control. 2025–2026 Thomas Built HDX, HDX2, Saf-T-Liner C2 +2 more
- Thomas Built emergency Exit Label lettering is too small and may be difficult to read. 2019–2020 Thomas Built HDX, Minotour DRW, Minotour SRW +3 more
- Thomas Built Buses front axle tie rod ball joint studs may crack and break, which can result in tie rod separation. 2024–2025 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built Buses wheel hub fasteners may loosen and cause the wheel to detach, which can result in a loss of vehicle control. 2025 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built tie rod may be missing a fastener, allowing the steer arm to detach. 2023 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner C2 Jouley +2 more
- Thomas Built exterior roof panel was manufactured with insufficient joint strength. 2011 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built Buses buses may not have a sufficient number of emergency exits. 2023 Thomas Built Buses Saf-T-Liner Efx
- Thomas Built passenger seat frames may crack and rotate from fatigue. 2014 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built Buses passenger seat mounting bolts may break due to improperly placed mounting that allows contact with the chassis cross member bolts. 2020 Thomas Built Buses Saf-T-Liner Efx
- Thomas Built nut for the power cable stud on the alternator may not have been tightened properly, which can cause a loose cable connection. 2020 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built steering arm and tie rod bolts may have a defective seam that can fracture. 2021 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built on certain vehicles, one of the six brake caliper mounting bolts on the driver side steer axle may have been incorrectly tightened. 2021 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built brake caliper mounting bolts may have been insufficiently tightened. 2019 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built seats may have been manufactured with styrene blocks that may not provide sufficient impact absorption in certain specific areas around the steel seat frame of the back support. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. 2019 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built driver side rear brakes may drag. 2010–2017 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built affected vehicles may have loose steering tie rod arm bolts. 2018 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built brake caliper mounting bolts may have been insufficiently tightened. 2018 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built Buses check valve for the air brake system may not be plumbed correctly which can cause the primary air system to not be isolated from the secondary air system. 2017 Thomas Built Buses Saf-T-Liner Efx
- Thomas Built Buses check valve for the air brake system may not be plumbed correctly which can cause the primary air system to not be isolated from the secondary air system. 2017 Thomas Built Buses Saf-T-Liner Efx
- Thomas Built brake caliper mounting bolts on these vehicles may be insufficiently tightened, allowing the bolts to loosen. 2017 Thomas Built HDX, Saf-T-Liner C2, Saf-T-Liner Efx
- Thomas Built wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built wall mounting bracket may crack, causing the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built wall mounting bracket may crack, which may cause the seat to not remain secured in place in the event of a crash. 2014 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built under load, the seat belt buckle mount rod can fracture. 2016 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built occupant seats may have been installed without under-rail washers, reducing their anchorage strength. 2014 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. 2015 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built affected stop arms have a reflective decal that may peel loose from the stop arm. 2016 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built in the event of a severe rear-end collision, the seats may tilt rearward. 2016 Thomas Built HDX, Minotour, Saf-T-Liner C2 +1 more
- Thomas Built affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. 2006 Thomas Built HDX, Minotour, Saf-T-Liner Ef +1 more
- Thomas Built affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. 2006 Thomas Built HDX, Minotour, Saf-T-Liner C2 +3 more
- Thomas in the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode. 2001–2013 Thomas Saf-T-Liner Conventional, HDX, SAF-T-LINER ER +7 more
- Thomas in the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode. 2001–2013 Thomas Saf-T-Liner Conventional, HDX, SAF-T-LINER ER +7 more
- Thomas Built Buses in the affected vehicles, due to an incorrect calibration, the speedometer may display a speed lower than the vehicle is actually traveling. 2014 Thomas Built Buses Saf-T-Liner Efx
- Thomas Built U-bolt intended to reinforce certain seat installations to the chassis may have been left out of the assembly process. 2012 Thomas Built HDX, Saf-T-Liner Efx
- Thomas Built information label affixed to the auxiliary heater fuel pickup tube may detach and fall off into the fuel tank, inhibiting fuel delivery to the engine. 2013 Thomas Built HDX, Saf-T-Liner Ef, Saf-T-Liner Efx
- Thomas Built information label affixed to the auxiliary heater fuel pickup tube may detach and fall off into the fuel tank, inhibiting fuel delivery to the engine. 2013 Thomas Built HDX, Saf-T-Liner Ef, Saf-T-Liner Efx
- Thomas Built Buses DRL circuit breaker may trip during continuous operation of the headlights in high beam mode. 2013 Thomas Built Buses Saf-T-Liner Efx