Toyota recalls — Page 3
- BMW weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail. 2020 BMW Z4, Supra
- Lexus low-pressure fuel pump inside the fuel tank may fail. 2017–2019 Lexus ES350, GS, GS300 +24 more
- Toyota incorrect seat trim covers on one or both of the front seats can prevent the seat-mounted side air bag from deploying properly. 2020 Toyota Highlander
- BMW headlamps are able to be adjusted horizontally. 2019–2020 BMW Z4, Supra
- Toyota due to a wiring error, the front turn signals may not flash brightly enough. 2018 Toyota Tundra
- Toyota excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven. 2013–2014 Toyota Prius, Prius V
- Toyota water may enter through the steering gear box cover and cause a loss of electric power steering assist. 2019 Toyota RAV4
- BMW in certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod. 2019–2020 BMW 330i, M340i, X3 +3 more
- Toyota front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly. 2019 Toyota RAV4
- Toyota rear hatch wire harness connector may have been damaged during assembly, which may cause the back-up lights to fail. 2020 Toyota Corolla
- Toyota due to an Engine Control Unit (ECU) programming error, fuel may not be correctly supplied to the engine while using the stop and restart feature. 2020 Toyota Highlander
- Lexus porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally. 2019–2020 Lexus ES, Avalon, Camry +1 more
- Toyota equipped with Non-Azide Driver air bag Inflators (nadi) and do not contain phase stabilized ammonium nitrate (psan) propellant. 1997–1998 Toyota Celica, RAV4, Supra
- Toyota during certain crashes, the air bag electronic control unit (ECU) may malfunction, possibly disabling the deployment of the air bags and/or seat belt pretensioners. 2011–2012 Toyota Avalon, Corolla, Matrix
- Lexus toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. 2013–2018 Lexus ES350, GS, GS300 +24 more
- Toyota electrical short circuit in the combination meter could occur, causing the speedometer, the odometer, and the fuel gauge to go blank. 2019 Toyota Prius
- Toyota seat belt webbing sensor locking mechanism may not lock as intended. 2019–2020 Toyota C-HR, Corolla
- BMW headlight control units may fail causing a loss of one or both of the headlights. 2020 BMW 330i, Z4, Supra
- Lexus had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. 2002–2011 Lexus ES350, GX460, IS +10 more
- BMW back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. 2018–2020 BMW 330i, 530e, 530i +22 more
- Toyota during installation, certain steering and suspension components may not have been properly tightened. 2018 Toyota 4Runner
- Toyota driver's seat belt guide loop mount may have been improperly welded. 2020 Toyota Supra
- Pontiac air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly. 2003–2005 Pontiac Vibe, Corolla, Corolla Matrix
- Toyota due to a damaged electrical connector, the back-up camera may not activate when the vehicle is in reverse. 2019 Toyota RAV4
- Toyota occupant Classification System (OCS) may have been improperly calibrated, which may prevent the proper deployment of the front passenger air bag and knee air bag, in the event of a crash. 2019 Toyota Camry
- Toyota rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm. 2012 Toyota Sienna
- Lexus brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. 2019–2020 Lexus ES, LC500, LS +5 more
- Toyota steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture. 2017 Toyota Sienna
- Toyota load carrying capacity modification label may be incorrect. 2017 Toyota Camry, Corolla, RAV4 +2 more
- Toyota DC-DC converter may fail resulting in the auxiliary battery no longer receiving power from the converter, which may cause a loss of drive. 2018 Toyota Prius C
- Toyota brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system. 2014 Toyota Sienna
- Toyota passenger front door may have incorrect welds inside, possibly affecting the air bag sensor readings for the passenger side front seat and curtain shield air bags. 2019 Toyota Sienna
- Toyota wire harnesses for the side air bag sensors located within the front doors may crack and corrode, possibly causing the non-deployment or improper deployment of the front seat side air bags and the curtain shield air bags. 2015 Toyota Yaris
- Toyota text on the load capacity label may become illegible. 2019 Toyota 4Runner, Avalon, C-HR +11 more
- Toyota fuel filler pipe may not have been properly reconnected to the fuel tank during an inspection after vehicle assembly. 2019 Toyota Avalon, Camry
- Lexus virgin Islands or "Zone A." Toyota is also recalling certain 2011-2013 Toyota Corolla, Corolla Matrix, Lexus IS250, IS350, 2011-2016 4Runner, 2011-2015 Scion xB, Lexus IS350C, IS250C, 2011-2014 Toyota Sienna, Lexus IS-F, 2011-2017 Lexus GX460, and 2011-2012 Lexus ES350 vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Toyota is also recalling certain 2010-2013 Toyota Corolla, Corolla Matrix, Lexus IS350, 2010-2016 4Runner, 2010-2013 Lexus IS250, 2010-2015 Scion xB, Lexus IS350C, IS250C, 2010-2017 Lexus GX460, 2010-2014 Lexus IS-F, and 2010-2012 Lexus ES350 vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling. 2010–2011 Lexus ES350, GX460, IS +5 more
- Toyota load carrying capacity modification label may have been incorrectly calculated. 2019 Toyota Tundra
- Toyota pump impeller blades within the torque converter may detach, especially when driven under high load, potentially causing a vehicle stall. 2019 Toyota Corolla
- Lexus over time, the seat belt tension sensor wire harness may break and deactivate the front passenger air bag, knee air bag, and passenger seat-mounted side airbag. 2008 Lexus LX570, Land Cruiser
- Toyota improper machining of the brake master cylinder may result in internal damage of one of the seals, affecting brake performance. 2018 Toyota Tacoma
- Lexus are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. 2002–2003 Lexus SC, Vibe, Corolla +2 more
- Toyota gross Vehicle Weight Rating (gvwr) on the certification label may be incorrect, possibly resulting in the vehicle being overloaded. 2017 Toyota 4Runner
- Toyota rear axle hub bearing bolts may have been insufficiently tightened, causing the bolts to loosen and damage the rear brake components or cause a rear wheel to detach. 2019 Toyota C-HR
- Toyota accessory all-weather floormats may have been counted twice when creating the load carrying capacity modification label, resulting in the capacity modification label incorrectly overstating the additional weight by 10 pounds. 2018 Toyota Tundra
- Toyota excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven. 2010–2012 Toyota Prius, Prius V
- Toyota air bag electronic control unit (ECU) may erroneously detect a fault during the vehicle start-up self check. 2018–2019 Toyota Avalon, Sequoia, Tundra
- Toyota portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit. 2016 Toyota Prius
- Toyota during a vehicle repair, the seat belt inner buckles may have been replaced with parts that may incorrectly tell the air bag management system that the seat belt is always buckled. 2012 Toyota Avalon
- Lexus during the manufacturing process, the oil galley in the rotor for the brake booster vacuum pump assembly may have been improperly machined possibly resulting in a sudden loss of brake assist. 2017–2018 Lexus RX350, Camry, Highlander +2 more
- Toyota pistons on these vehicles may be larger than specified, possibly causing the engine to stall. 2018 Toyota Camry