Volvo recalls — Page 2
- Volvo castellated nut securing the steering gear link rod to the steering arm may be loose and allow the link rod to detach. 2024 Volvo 9700 DO NOT DRIVE
- Volvo diagnostic error in the Central Electronic Module (CEM) software may cause the left rear turn signal indicator to not function. 2024 Volvo XC40
- Volvo steering gear assembly may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control. 2020 Volvo VNL
- Volvo bearing journals may not be fully seated in the steering knuckle assembly, preventing the proper installation of the wheel end hub assembly. 2024 Volvo VNL
- Volvo red beacon lighting on the Threshold Warning System (TWS) may not be bright enough. 2013 Volvo 9700
- Volvo second-row seat belt buckle and lower belt anchor bolts may not be tightened properly. 2015 Volvo XC90
- Volvo gross Axle Weight Rating (gawr) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded. 2024 Volvo VHD, VN
- Volvo engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected. 2023 Volvo VN
- Volvo passenger air bag may not be secured properly, which can cause the air bag to deploy improperly. 2019 Volvo S60
- Volvo passenger side bench seat may be inadequately attached to the floor. 2019 Volvo VHD, VN
- Volvo software programming error may cause the electronic stability control (ESC) to be inoperative. 2024 Volvo VNL, VNR
- Volvo fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control. 2024 Volvo VHD, VNL, VNR
- Volvo emergency window exits may be missing identification and operating instruction labels. 2023 Volvo 9700
- Volvo fasteners that secure the power cable connections may not have been tightened securely. 2023 Volvo 9700
- Volvo windshield wiper motor gears may wear prematurely, causing the motor to fail. 2022 Volvo VAH, VHD, VNL +1 more
- Volvo rivnut threaded inserts inside the high-voltage battery may be over-tightened and break, which could result in a short circuit. 2020 Volvo Vnre (Electric)
- Volvo steering gear fasteners may not be properly tightened. 2023 Volvo VAH, VHD, VN
- Volvo power cables that connect to the windscreen heater relay may have a loose connection and cause the relay to fail. 2019 Volvo Vnre (Electric)
- Volvo missing circuit will prevent the side air bag from deploying during a crash. 2022 Volvo VHD, VNL
- Volvo coolant line in the high voltage battery pack may not be fully seated and locked, which can result in the loss of coolant and an electrical short circuit. 2020 Volvo VNR
- Volvo when the adaptive cruise control braking activates under light load conditions, it can trigger an aggressive braking response. 2020 Volvo VNR
- Volvo diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM). 2023 Volvo C40BEV, S60, V60CC +3 more
- Volvo hub covers do not properly fit on the hub and can detach from the vehicle. 2024 Volvo VHD, VNL, VNR
- Volvo cabin heater relay may fail, causing the coolant heater to overheat. 2019 Volvo Vnre (Electric)
- Volvo diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control. 2023 Volvo C40BEV, S60, V60 +5 more
- Volvo during steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing. 2019 Volvo V60CC, XC60, XC90
- Volvo GPS devices may have been installed incorrectly, which can cause an accelerator pedal sensor malfunction and lead to an unexpected loss of drive power. 2022 Volvo 9700
- Volvo air tank bracket fasteners were excessively tightened and may have broken. 2022 Volvo VNL
- Volvo emergency light sensors may have been installed incorrectly, causing the emergency lights to fail to activate after a rollover event. 2023 Volvo 9700
- Volvo electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power. 2022 Volvo S60, S90, V60 +2 more
- Volvo coolant line in the high voltage battery pack may not be fully seated and locked, which can result in the loss of coolant and an electrical short circuit. 2022 Volvo Vnre (Electric)
- Volvo engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall. 2023 Volvo VN
- Volvo steering gears may have been assembled incorrectly, which can cause the gear to fracture. 2022 Volvo VN
- Volvo water may enter the cable harness, corroding the accelerator pedal sensor (APS) circuit. 2021 Volvo XC40BEV
- Volvo in the event of the alternator front bearing seizing, the alternator belt may continue to operate, causing the bearing to overheat. 2020 Volvo 9700
- Volvo cabinets may be improperly secured to the walls due to the bolts being installed without the required washers. 2022 Volvo VN
- Volvo bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing. 2021 Volvo XC40
- Volvo machining defect may cause pressure to build in the power steering pump, breaking the shaft seal and resulting in a loss of power steering assist. 2021 Volvo VNL
- Volvo driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling. 2001 Volvo V70, XC70
- Volvo electronic control unit software may allow the transmission to shift into neutral unexpectedly. 2022 Volvo VNL
- Volvo driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling. 2001 Volvo S60, S80
- Volvo improperly welded rotor and shaft may separate within the integrated brake system. 2020–2021 Volvo S90, XC60, XC90
- Volvo headlights may not have the correct amount of light output, and either be too bright, or too dim. 2008 Volvo 9700
- Volvo seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. 2021 Volvo S60, V60, V60CC +5 more
- Volvo when the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. 2009 Volvo 9700
- Volvo low-pressure fuel pump can blow a fuse and fail. 2019 Volvo S60, S90, V60 +5 more
- Volvo hubcap compression spring can cause the hubcap to separate. 2021 Volvo VAH, VHD, VNL +1 more
- Volvo liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible. 2016 Volvo XC90
- Volvo battery Energy Control Module (becm) microprocessor may reset and cause the high voltage system to disconnect. 2021 Volvo XC40
- Volvo under certain circumstances, these wheels may not be able to support the load, which can cause the wheels to bend or break while in use. 2022 Volvo VNL