Volvo VHD recalls
- Volvo steering knuckles may have been manufactured with insufficiently tightened steering arms. 2026 Volvo VAH, VHD, VN +2 more
- Volvo wheel lug nuts may loosen and allow the wheel to detach. 2026–2027 Volvo VAH, VHD, VN +2 more DO NOT DRIVE
- Volvo electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working. 2020 Volvo VAH, VHD, VN +1 more
- Volvo wheel lug nuts may be improperly tightened. 2025 Volvo VHD, VN
- Volvo tie rod assembly ball stud could have been improperly heat treated and can fail. 2025 Volvo VHD, VN
- Volvo drag link may contain an improperly heat-treated ball stud that can fail, resulting in a sudden loss of steering control. 2025 Volvo VHD, VN, Vnre (Electric) DO NOT DRIVE
- Volvo steering gear may have an improperly seated plug in the valve housing, which can result in a sudden loss of steering control. 2025 Volvo VHD, VN
- Volvo gross Axle Weight Rating (gawr) listed on the vehicle certification label is incorrect, which can allow the vehicle to be overloaded. 2024 Volvo VHD, VN
- Volvo passenger side bench seat may be inadequately attached to the floor. 2019 Volvo VHD, VN
- Volvo fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control. 2024 Volvo VHD, VNL, VNR
- Volvo windshield wiper motor gears may wear prematurely, causing the motor to fail. 2022 Volvo VAH, VHD, VNL +1 more
- Volvo steering gear fasteners may not be properly tightened. 2023 Volvo VAH, VHD, VN
- Volvo missing circuit will prevent the side air bag from deploying during a crash. 2022 Volvo VHD, VNL
- Volvo hub covers do not properly fit on the hub and can detach from the vehicle. 2024 Volvo VHD, VNL, VNR
- Volvo hubcap compression spring can cause the hubcap to separate. 2021 Volvo VAH, VHD, VNL +1 more
- Volvo collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing. 2021 Volvo VAH, VHD, VNL +1 more
- Volvo king pin nut may not have been installed or properly tightened during axle assembly. 2021 Volvo VHD, VNL, VNR
- Volvo die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging. 2020 Volvo VAH, VHD, VNL +1 more
- Volvo fuse in the transmission circuit may blow, preventing the transmission from shifting. 2018 Volvo VAH, VHD, VNL +1 more
- Volvo t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored. 2019 Volvo VAH, VHD, VNL +1 more
- Volvo sidewall steel body cords may be exposed, possibly causing unexpected, rapid air loss during use. 2019 Volvo VHD, VNL
- Volvo snow plow headlights can be turned on without other exterior lights, and high beam indicator will not work when the snow plow high beams are on. 2004 Volvo VHD
- Volvo gross Axle Weight Rating (gawr) for the pusher or tag axle may be incorrect on the certification label. 2015 Volvo VHD
- Volvo affected vehicles were built with front wheel hubs that cannot support the gross axle weight rating of the front axle. 2017 Volvo VHD, VNL, VNM
- Volvo ball joint seals may be compromised, which can allow water and other contaminants to enter the ball joints. 2009 Volvo VHD
- Volvo affected vehicles may be equipped with headlights that do not meet the minimum intensity requirements, resulting in insufficient illumination of the roadway. 2015 Volvo VAH, VHD
- Volvo affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature. 2012–2014 Volvo VHD, VNL, VNM
- Volvo when the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. 2014 Volvo VAH, VHD, VNL +1 more
- Volvo windshield wiper motor may fail. 2011 Volvo VAH, VHD, VNL +1 more
- Volvo affected vehicles were built without a redundant clutch disengagement switch. 2007 Volvo VAH, VHD, VNL +2 more
- Volvo are equipped with an MGM Type 24 J-series piston parking brake chamber. 2011 Volvo VHD, VNL
- Volvo remote battery disconnect switch was manufactured with incorrect hardware allowing the cables to loosen. 2012 Volvo VHD, VNL, VNM
- Volvo seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. 2002 Volvo VHD, VN
- Volvo in extremely cold conditions, these bendix relay valves may potentially develop internal leakage. 2011 Volvo VHD, VNL, VNM
- Volvo tubing used to assemble the drivelines has a nonconforming seam weld with insufficient bonding of the material. 2012 Volvo VHD, VNL, VNM
- Volvo due to an incomplete "knitting" of the iron at the time of casting, inadequate structural integrity of the slack adjuster housing can occur, which could cause the housing to break at the handle under normal operating loads. 2011–2012 Volvo VHD, VNL, VNM
- Volvo inversion valve on the frame may be orientated where contaminants can enter the valve through the exhaust port. 2006–2007 Volvo VHD, VN, VT
- Volvo official notice describes a safety defect, but the details were not provided in plain language. 2008 Volvo VHD, VNL, VNM +1 more
- Volvo on certain trucks, the hood restraint cylinder does not contain enough dampening to adequately restrain the hood. 2008 Volvo VHD, VNL, VNM +1 more
- Volvo on certain trucks, an unprotected lead in the thermoswitch of the heater may make contact with another post possibly creating a short circuit, which can result in continuous operation of the heating element. 2007 Volvo VHD, VNL, VNM +1 more
- Volvo on certain heavy duty class 8 trucks equipped with dana steering shafts, there is a potential that the steering shaft pinch bolt hole may be incorrectly located. 2007 Volvo VHD, VN, VT
- Volvo certain trucks fail to conform to the requirements of federal motor vehicle safety standard no. 2003 Volvo VHD