Volvo VNL recalls
- Volvo steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture. 2024 Volvo VNL, VNR
- Volvo steering gear assembly may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control. 2020 Volvo VNL
- Volvo bearing journals may not be fully seated in the steering knuckle assembly, preventing the proper installation of the wheel end hub assembly. 2024 Volvo VNL
- Volvo software programming error may cause the electronic stability control (ESC) to be inoperative. 2024 Volvo VNL, VNR
- Volvo fastener that connects two steering components, the pitman arm and draglink, may be loose, which can cause the connection to fail and result in a loss of steering control. 2024 Volvo VHD, VNL, VNR
- Volvo windshield wiper motor gears may wear prematurely, causing the motor to fail. 2022 Volvo VAH, VHD, VNL +1 more
- Volvo missing circuit will prevent the side air bag from deploying during a crash. 2022 Volvo VHD, VNL
- Volvo hub covers do not properly fit on the hub and can detach from the vehicle. 2024 Volvo VHD, VNL, VNR
- Volvo air tank bracket fasteners were excessively tightened and may have broken. 2022 Volvo VNL
- Volvo machining defect may cause pressure to build in the power steering pump, breaking the shaft seal and resulting in a loss of power steering assist. 2021 Volvo VNL
- Volvo electronic control unit software may allow the transmission to shift into neutral unexpectedly. 2022 Volvo VNL
- Volvo hubcap compression spring can cause the hubcap to separate. 2021 Volvo VAH, VHD, VNL +1 more
- Volvo under certain circumstances, these wheels may not be able to support the load, which can cause the wheels to bend or break while in use. 2022 Volvo VNL
- Volvo capscrews that attach the flywheel to the crankshaft may have been improperly torqued, allowing the flywheel to detach. 2022 Volvo VNL
- Volvo collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing. 2021 Volvo VAH, VHD, VNL +1 more
- Volvo window hinge and mounting hardware are insufficient to hold the window in place if the truck is driven with the sleeper bunk windows open. 2020 Volvo VNL
- Volvo king pin nut may not have been installed or properly tightened during axle assembly. 2021 Volvo VHD, VNL, VNR
- Volvo die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging. 2020 Volvo VAH, VHD, VNL +1 more
- Volvo gross Axle Weight Rating (gawr) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. 2018 Volvo VNL, VNR
- Volvo steering gear fasteners may have not been properly tightened. 2020 Volvo VNL, VNR
- Volvo steering gear mounting fasteners may be insufficiently tightened, allowing the steering gear to loosen. 2020 Volvo VNL, VNR
- Volvo axles missed the heat treating operation during manufacturing, reducing their strength and possibly causing the axle beams to fracture. 2015 Volvo VNL
- Volvo fuse in the transmission circuit may blow, preventing the transmission from shifting. 2018 Volvo VAH, VHD, VNL +1 more
- Volvo t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored. 2019 Volvo VAH, VHD, VNL +1 more
- Volvo sleeper bunk window may detach and fall from the vehicle. 2018 Volvo VNL, VNX
- Volvo internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement. 2018 Volvo VNL
- Volvo sidewall steel body cords may be exposed, possibly causing unexpected, rapid air loss during use. 2019 Volvo VHD, VNL
- Volvo in certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted. 2016 Volvo VNL
- Volvo fifth wheel may have an outboard slider bracket that is too narrow, possibly allowing the trailer to separate from the tractor. 2019 Volvo VNL, VNR
- Volvo castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen. 2016 Volvo VNL, VNM
- Volvo affected vehicles were built with front wheel hubs that cannot support the gross axle weight rating of the front axle. 2017 Volvo VHD, VNL, VNM
- Volvo in the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system. 2013–2017 Volvo VNL, VNM, VNX
- Volvo are equipped with certain Meritor FF967 non-drive front steer axles that may have been incorrectly heat treated. 2013 Volvo VNL, VNM
- Volvo these ECM's may experience an internal electrical short that can cause a fuse to blow, resulting in an unexpected engine stall without the ability to restart the engine. 2017 Volvo VNL
- Volvo affected vehicles are equipped with USK non-greasable drag links that may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint. 2009–2016 Volvo VNL, VNM, VT
- Volvo trucks may have been manufactured without a roll pin on the steering shafts. 2016 Volvo VNL, VNM, VNX DO NOT DRIVE
- Volvo affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage. 2011 Volvo VAH, VNL, VNM
- Volvo affected APUs have metal housings whose mounting points may crack and tear. 2012 Volvo VNL
- Volvo in the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel. 2012 Volvo VNL, VNM
- Volvo affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator. 2015 Volvo VNL, VNX
- Volvo affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature. 2012–2014 Volvo VHD, VNL, VNM
- Volvo affected vehicles may experience premature tire failure during certain operating conditions such as high speeds, heavy load, and high road temperature. 2011 Volvo VAH, VNL
- Volvo due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate. 2014 Volvo VAH, VNL, VNM
- Volvo due to the engine control unit having an incorrect parameter setting in the software, the engine may stall. 2015 Volvo VNL, VNX
- Volvo in the affected vehicles, the active braking component of the enhanced cruise control can become disabled. 2011–2014 Volvo VNL, VNM
- Volvo condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. 2013 Volvo VNL, VNM
- Volvo when the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. 2014 Volvo VAH, VHD, VNL +1 more
- Volvo windshield wiper motor may fail. 2011 Volvo VAH, VHD, VNL +1 more
- Volvo driveshaft is too weak for this application and may fail. 2013 Volvo VNL
- Volvo affected vehicles were built without a redundant clutch disengagement switch. 2007 Volvo VAH, VHD, VNL +2 more