Gillig recalls
Models
- Gillig rear Gross Axle Weight Rating (gawr) on the federal placard may exceed the tire load rating. 2023 Gillig Low Floor
- Gillig air compressor intake pipe may contact and damage the fuel line. 2021 Gillig Low Floor
- Gillig high voltage cable, connecting the inverter to the drive unit, contains a splice connection that reduces the amp capacity rating. 2023 Gillig Low Floor
- Gillig rear axle upper torque rod fasteners may have been improperly tightened. 2025 Gillig Low Floor
- Gillig retractors may not lock, preventing the wheelchair from being properly secured. 2025 Gillig Low Floor
- Gillig emergency exit window latch may fail, allowing the window to open during a crash. 2013 Gillig Low Floor
- Gillig high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit. 2023 Gillig Low Floor
- Gillig rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall. 2019 Gillig Low Floor
- Gillig fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail. 2021 Gillig Low Floor
- Gillig high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (hvil). 2023 Gillig Low Floor
- Gillig during vehicle operations in full electric vehicle (EV) mode, the odometer will not display accumulated mileage. 2023 Gillig Low Floor
- Gillig defective welded joint may cause the wiper arm to suddenly fail. 2024 Gillig Low Floor
- Gillig steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen. 2023 Gillig Low Floor
- Gillig insufficient crimping may allow the remote fuel filter hoses to disconnect and leak, decreasing fuel supply to the engine. 2023 Gillig Low Floor
- Gillig inadequate amount of lubricant in the rear axle hubs may cause failure of the rear drive axles. 2023 Gillig Low Floor
- Gillig rearview mirror electric adjustment system may have been manufactured with an incorrect fuse. 2021 Gillig Low Floor
- Gillig transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power. 2019 Gillig Low Floor
- Gillig driveshaft fasteners may have been improperly tightened after service repairs, allowing the driveshaft to detach. 2022 Gillig Low Floor
- Gillig electrical failure may cause a short-circuit in the fuse box mounted underneath the driver's seat platform. 2022 Gillig Low Floor
- Gillig rear suspension lower control arm may fail. 2011 Gillig Low Floor 29 Foot
- Gillig incompatible steering system draglink parts may have been installed during the vehicle assembly process, potentially resulting in long-term damage of the steering system. 2022 Gillig Low Floor
- Gillig steering shaft grease fitting may contact and damage the protective shroud. 2022 Gillig Low Floor
- Gillig battery packs may develop a coolant leak internally, causing the battery pack to short circuit. 2019 Gillig Low Floor
- Gillig EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Drive to Neutral with no warning. 2019 Gillig Low Floor
- Gillig rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position. 2014 Gillig Low Floor
- Gillig when a system shutdown occurs, the high voltage shutdown override switch may not function, with no warning to the driver. 2020 Gillig Low Floor Electric
- Gillig fuel leak may occur from the fuel hose between the fuel pump and the remote fuel filter head. 2020 Gillig Low Floor
- Gillig engine calibration software's management of the injection of Diesel Exhaust Fluid can allow excessive ammonia into the tailpipe exhaust. 2020 Gillig Low Floor
- Gillig rear axle may come out of alignment during operation. 2020 Gillig Low Floor, Low Floor 29 Foot, Low Floor Electric
- Gillig sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2017 Gillig Low Floor
- Gillig overlap between the curb side and street side roof doors is insufficient and may allow the street side door to accidentally open. 2020 Gillig BRT, Low Floor
- Gillig shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist. 2013 Gillig Low Floor
- Gillig rear suspension lower control rods may experience fatigue failure due to stiffened end bushings. 2018 Gillig Low Floor
- Gillig thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing. 2018 Gillig Low Floor
- Gillig circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector. 2012 Gillig Low Floor
- Gillig temperature and vibration stresses may cause the tempered glass roof hatch to shatter. 2018 Gillig Low Floor
- Gillig uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights. 2014 Gillig Low Floor
- Gillig ball stud of the steering system draglink may not have been properly tightened. 2016 Gillig Low Floor
- Gillig as built, one of the emergency exit windows may not be able to be easily used in the event of an emergency. 2016 Gillig Low Floor
- Gillig spring cage bolts on the air brakes may not be sufficiently tightened, reducing the effectiveness of the parking brake. 2013 Gillig Low Floor
- Gillig pressure switches on these Drive Units may fail, possibly resulting in a loss of drive. 2017 Gillig Low Floor
- Gillig front and rear turn signals on these vehicles may flash at different rates, potentially confusing other drivers of the vehicle's intention. 2012 Gillig Low Floor
- Gillig turn signals may flash slowly, reducing their visibility to other drivers. 2001 Gillig Low Floor
- Gillig coupler between the high-voltage electric motor and hydraulic steering pump shafts may fail, resulting in a loss of power steering assist. 2013 Gillig Low Floor
- Gillig in the affected seats, the seat belt buckle may be stuck in the locked position, preventing the seat belt tongue from being able to be inserted and locked. 2016 Gillig Low Floor
- Gillig suspension kneeling modules on these vehicles have snap rings on the solenoid valve pistons which may not have been fully inserted and seated during assembly, potentially affecting the suspension air bag pressure and the vehicle's suspension height. 2015 Gillig Low Floor
- Gillig affected vehicles have wiper arms that can crack where they mount to the wiper motor causing the wiper arms to bend or detach from the vehicle. 2016 Gillig Low Floor
- Gillig front turn signals installed on standard profile (non-BRT) buses may not be sufficiently visible to other drivers or pedestrians. 1997 Gillig Low Floor
- Gillig have front LED turn signals with integrated side reflex reflectors that may not be sufficiently visible to other drivers or pedestrians. 2016 Gillig Low Floor
- Gillig these buses have gas detection electronics that may be disabled without providing the operator with a warning of a system malfunction. 2015 Gillig Low Floor