Spartan Fire Gladiator recalls
- Spartan Fire actuator lever arm in the cab door latch may bind or become wedged, preventing the door from opening. 2024 Spartan Fire FC-94, Gladiator, METROSTAR
- KME actuator lever arm in the cab door latch may bind or become wedged, preventing the door from opening. 2023–2024 KME Panther, Predator, FC-94 +2 more
- KME missing mechanical stop may allow the cab tilt cylinder to be overextended. 2024–2025 KME Panther, FC-94, Gladiator +1 more
- KME lower control arm retention bolts could become brittle and break after being tightened. 2023 KME Panther, Gladiator, METROSTAR
- Spartan Fire service brake may take longer than expected to engage. 2017–2018 Spartan Fire Gladiator, METROSTAR
- Spartan Fire seat mount fastener may be undersized and could break. 2022–2023 Spartan Fire FC-94, Gladiator, METROSTAR
- KME in the event of a short circuit or wiring failure, the firmware in the node may fail to shut off the output pin, resulting in overloaded electrical circuits. 2023–2024 KME Panther, Commercial, FC-94 +2 more
- Spartan Fire defect in the inversion valve may delay the park brake setting after engagement, which could allow the vehicle to move unintentionally. 2021 Spartan Fire FC-94, Gladiator, METROSTAR
- KME defect in the inversion valve may delay park brake engagement, which could allow the vehicle to move unintentionally. 2021–2023 KME Panther, Predator, FC-94 +2 more
- Spartan Fire rope rescue anchor point (hoist ring) may have been improperly assembled, which can allow a hinge pin to separate from the ring. 2018–2020 Spartan Fire Gladiator, METROSTAR
- KME after the vehicle is reversed, the transmission control module (TCM) may fail to achieve the 4th gear lockup needed to initiate the water pump. 2022 KME Panther, FC-94, Gladiator +1 more
- Spartan Fire front-drive steer axle fasteners may loosen, resulting in a complete separation of the axle assembly joints. 2020–2023 Spartan Fire Gladiator, METROSTAR
- KME tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the tie rods to separate. 2021 KME Panther, FC-94, Gladiator +1 more
- KME tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the tie rods to separate. 2021 KME Panther, FC-94, Gladiator +1 more
- Spartan Fire front wheel parking brake may not engage. 2022 Spartan Fire Gladiator, METROSTAR
- Spartan Fire there may be a loose neutral screw connection within the QO Plug-On Neutral Load Center. 2020 Spartan Fire Gladiator, METROSTAR
- Spartan Fire additional resistor was incorrectly installed on the printed circuit board, which can disrupt CAN network communication and cause vehicle lighting to fail. 2021–2022 Spartan Fire FC-94, Gladiator, METROSTAR
- Spartan Fire rear axle drive pinion may fracture. 2021 Spartan Fire Gladiator, METROSTAR
- Spartan Fire fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak. 2019 Spartan Fire Gladiator, METROSTAR
- Spartan Fire rear axle drive pinion may fracture. 2020–2021 Spartan Fire FC-94, Gladiator, METROSTAR
- Spartan Fire pump shift solenoid may corrode internally, causing a loss of power to the pump control module. 2009 Spartan Fire Gladiator, METROSTAR
- Spartan Fire these displays may experience low voltage spikes causing the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2020 Spartan Fire Gladiator, METROSTAR
- Spartan Fire sealing washer may not seat correctly in the pilot boreholes, allowing the high-pressure fuel rail assembly to leak. 2017 Spartan Fire Gladiator, METROSTAR
- Spartan Fire pressure may build in the power steering pump and break the shaft seal, resulting in a loss of power steering assist. 2019 Spartan Fire Gladiator, METROSTAR
- Spartan Fire fire water pump solenoid may corrode internally, causing a loss of power to the pump control module. 2009 Spartan Fire Gladiator, METROSTAR
- Spartan Fire sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2017 Spartan Fire Gladiator, METROSTAR
- Spartan Fire pressure may build in the power steering pump and break the shaft seal, resulting in a loss of power steering assist. 2019 Spartan Fire Gladiator, METROSTAR
- Spartan Fire steering gear mounting bolts may become loose and back out, resulting in difficulty steering. 2019 Spartan Fire Gladiator, METROSTAR
- Spartan Fire these displays may experience low voltage spikes, and cause the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2020 Spartan Fire Gladiator, METROSTAR
- Spartan Fire these displays may experience low voltage spikes, and cause the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2019 Spartan Fire Gladiator, METROSTAR
- Spartan Fire lights may be too bright, exceeding the maximum light output allowed which may adversely affect the vision of drivers. 2018 Spartan Fire Gladiator
- Spartan Fire monitor is used to direct the water stream and adjust the spray pattern. 2019 Spartan Fire Gladiator