Check your VIN

Spartan Fire recalls

39 recall campaigns for Spartan Fire, newest first.

Models

  1. Spartan Fire handle may detach from the ladder lock assembly, allowing the ground ladders to fall off. 2007–2021 Spartan Fire Legend Series, Star Series, Ust Body 25V-910 · December 23, 2025
  2. Spartan Fire actuator lever arm in the cab door latch may bind or become wedged, preventing the door from opening. 2024 Spartan Fire FC-94, Gladiator, METROSTAR 25V-758 · November 4, 2025
  3. KME actuator lever arm in the cab door latch may bind or become wedged, preventing the door from opening. 2023–2024 KME Panther, Predator, FC-94 +2 more 25V-584 · September 6, 2025
  4. KME missing mechanical stop may allow the cab tilt cylinder to be overextended. 2024–2025 KME Panther, FC-94, Gladiator +1 more 24V-799 · October 24, 2024
  5. KME lower control arm retention bolts could become brittle and break after being tightened. 2023 KME Panther, Gladiator, METROSTAR 24V-507 · July 2, 2024
  6. Spartan Fire service brake may take longer than expected to engage. 2017–2018 Spartan Fire Gladiator, METROSTAR 24V-453 · June 18, 2024
  7. Spartan Fire seat mount fastener may be undersized and could break. 2022–2023 Spartan Fire FC-94, Gladiator, METROSTAR 24V-323 · May 10, 2024
  8. KME in the event of a short circuit or wiring failure, the firmware in the node may fail to shut off the output pin, resulting in overloaded electrical circuits. 2023–2024 KME Panther, Commercial, FC-94 +2 more 24V-181 · March 7, 2024
  9. KME in the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits. 2020 KME Predator, Severe Service, METROSTAR 23V-818 · December 6, 2023
  10. KME in the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits. 2020–2022 KME Aerial Fire Apparatus, Pumper Fire Apparatus, Aerial +2 more 23V-808 · December 1, 2023
  11. Spartan Fire defect in the inversion valve may delay the park brake setting after engagement, which could allow the vehicle to move unintentionally. 2021 Spartan Fire FC-94, Gladiator, METROSTAR 23V-747 · November 7, 2023
  12. KME defect in the inversion valve may delay park brake engagement, which could allow the vehicle to move unintentionally. 2021–2023 KME Panther, Predator, FC-94 +2 more 23V-631 · September 12, 2023
  13. Spartan Fire rope rescue anchor point (hoist ring) may have been improperly assembled, which can allow a hinge pin to separate from the ring. 2018–2020 Spartan Fire Gladiator, METROSTAR 23V-389 · June 1, 2023
  14. KME after the vehicle is reversed, the transmission control module (TCM) may fail to achieve the 4th gear lockup needed to initiate the water pump. 2022 KME Panther, FC-94, Gladiator +1 more 23V-156 · March 23, 2023
  15. Spartan Fire front-drive steer axle fasteners may loosen, resulting in a complete separation of the axle assembly joints. 2020–2023 Spartan Fire Gladiator, METROSTAR 23V-192 · March 23, 2023
  16. Spartan Fire tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the tie rods to separate. 2021 Spartan Fire FC-94, METROSTAR 22V-879 · November 29, 2022
  17. KME tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the tie rods to separate. 2021 KME Panther, FC-94, Gladiator +1 more 22V-871 · November 23, 2022
  18. KME tie rod clamps may have been improperly heat-treated, causing them to fail and allowing the tie rods to separate. 2021 KME Panther, FC-94, Gladiator +1 more 22V-778 · October 17, 2022
  19. Spartan Fire precision Industries, Inc. 2021 Spartan Fire METROSTAR 22V-780 · October 17, 2022
  20. Spartan Fire front wheel parking brake may not engage. 2022 Spartan Fire Gladiator, METROSTAR 22V-682 · September 12, 2022
  21. Spartan Fire engine control module (ECM) may experience an internal short-circuit, which can result in an unexpected engine shut down. 2022 Spartan Fire METROSTAR 22V-625 · August 15, 2022
  22. Spartan Fire there may be a loose neutral screw connection within the QO Plug-On Neutral Load Center. 2020 Spartan Fire Gladiator, METROSTAR 22V-539 · July 26, 2022
  23. Spartan Fire additional resistor was incorrectly installed on the printed circuit board, which can disrupt CAN network communication and cause vehicle lighting to fail. 2021–2022 Spartan Fire FC-94, Gladiator, METROSTAR 22V-373 · May 24, 2022
  24. Spartan Fire rear axle drive pinion may fracture. 2021 Spartan Fire Gladiator, METROSTAR 22V-019 · January 20, 2022
  25. Spartan Fire fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak. 2019 Spartan Fire Gladiator, METROSTAR 21V-967 · December 13, 2021
  26. Spartan Fire rear axle drive pinion may fracture. 2020–2021 Spartan Fire FC-94, Gladiator, METROSTAR 21V-899 · November 18, 2021
  27. Spartan Fire pump shift solenoid may corrode internally, causing a loss of power to the pump control module. 2009 Spartan Fire Gladiator, METROSTAR 21V-567 · July 26, 2021
  28. Spartan Fire these displays may experience low voltage spikes causing the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2020 Spartan Fire Gladiator, METROSTAR 21V-535 · July 15, 2021
  29. Spartan Fire sealing washer may not seat correctly in the pilot boreholes, allowing the high-pressure fuel rail assembly to leak. 2017 Spartan Fire Gladiator, METROSTAR 21V-507 · July 2, 2021
  30. Spartan Fire pressure may build in the power steering pump and break the shaft seal, resulting in a loss of power steering assist. 2019 Spartan Fire Gladiator, METROSTAR 21V-458 · June 17, 2021
  31. Spartan Fire pump shift harness may have incorrect terminals, which could result in a poor electrical connection. 2019 Spartan Fire S-180 Pumper 21V-459 · June 17, 2021
  32. Spartan Fire fire water pump solenoid may corrode internally, causing a loss of power to the pump control module. 2009 Spartan Fire Gladiator, METROSTAR 21V-329 · May 10, 2021
  33. Spartan Fire sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak. 2017 Spartan Fire Gladiator, METROSTAR 21V-323 · May 6, 2021
  34. Spartan Fire pressure may build in the power steering pump and break the shaft seal, resulting in a loss of power steering assist. 2019 Spartan Fire Gladiator, METROSTAR 21V-252 · April 10, 2021
  35. Spartan Fire steering gear mounting bolts may become loose and back out, resulting in difficulty steering. 2019 Spartan Fire Gladiator, METROSTAR 21V-103 · February 22, 2021
  36. Spartan Fire these displays may experience low voltage spikes, and cause the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2020 Spartan Fire Gladiator, METROSTAR 20V-812 · December 28, 2020
  37. Spartan Fire these displays may experience low voltage spikes, and cause the LCD display to lock up or become nonfunctional, due to varying electrical installations. 2019 Spartan Fire Gladiator, METROSTAR 20V-762 · December 10, 2020
  38. Spartan Fire lights may be too bright, exceeding the maximum light output allowed which may adversely affect the vision of drivers. 2018 Spartan Fire Gladiator 20V-492 · August 19, 2020
  39. Spartan Fire monitor is used to direct the water stream and adjust the spray pattern. 2019 Spartan Fire Gladiator 20V-353 · June 15, 2020